BENDIXKing KY 97A Manual de Instalação

INSTALLATION MANUALKY 96A, KY 97AVHF COMMUNICATIONTRANSCEIVERMANUAL NUMBER 006-00674-0004Revision 4, April 2003h

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 1-41.4 UNITS AND ACCESSORIES SUPPLIEDNOTE: Not all configurations listed below are currentl

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 1-51.4.C. The KY 96A, KY 97A Installation Kit, P/N 050-02600-0000, which contains the follo

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 1-61.5 ACCESSORIES REQUIRED, BUT NOT SUPPLIED1.5.A. Communications antenna and cables.1.5.B

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 1-7function. When service is required, a complete performance test must be accom-plished f

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 1-8THIS PAGE RESERVED

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 2-1SECTION IIINSTALLATION2.1 GENERALThis section contains suggestions and factors to consid

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 2-2NOTE: Use good quality stranded wire with at least 600 V insulation that will not suppor

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 2-3nas provide efficient operation over the comm band. Antennas should be installed per ma

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 2-4Prior to insertion of connector into rear of unit, check polarizing key position between

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 2-5CAUTION: BEFORE FLIGHT, CHECK THE ANTENNA VSWR. THIS SHOULD BE CHECKED WITH AN IN-LINE

WARNINGTHE ENCLOSED TECHNICAL DATA IS ELIGIBLE FOR EXPORT UNDER LICENSE DES-IGNATION NLR AND IS TO BE USED SOLELY BY THE INDIVIDUAL/ ORGANIZATION TO W

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 2-6FIGURE 2-2 KY 96A Pin Function and Location Diagram

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 2-7FIGURE 2-3 KY 97A Pin Function and Location Diagram

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 2-8FIGURE 2-4 Molex Terminal and Tools (Sheet 1 of 3)

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 2-9FIGURE 2-4 Molex Terminal and Tools (Sheet 2 of 3)

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 2-10FIGURE 2-4 Molex Terminal and Tools (Sheet 3 of 3)

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 2-11FIGURE 2-5 KY 96A, KY 97A Outline and Mounting Drawing(Dwg No 155-05666-0001 Rev AB)

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 2-13FIGURE 2-6 KY 96A, KY 97A Installation Assembly Drawing(Dwg No 155-05690-0000 Rev 4)

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 2-15FIGURE 2-7 Connector (P/N 030-00101-0002 R-9) Assembly

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 2-16THIS PAGE RESERVED

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 2-17FIGURE 2-8 KY 96A interconnect(Dwg No 155-01583-0000 Rev AA)

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd RH-1REVISION HISTORYINSTALLATION MANUALBENDIX/KINGKY 96A, KY 97AVHF Communication TransceiverPAR

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 2-19FIGURE 2-9 KY 97A interconnect(Dwg No 155-01583-0001 Rev AA)

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 2-21FIGURE 2-10 Dual KY 96A interconnect(Dwg No 155-01584-0000 Rev AA)

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 2-23FIGURE 2-11 Dual KY 97A interconnect(Dwg No 155-01584-0001 Rev AA)

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 2-25FIGURE 2-12 Dual KY 96A with KA 25A interconnect(Dwg No 155-01585-0000 Rev AA)

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 2-27FIGURE 2-13 Dual KY 97A with KA 25A interconnect(Dwg No 155-01585-0001 Rev AA)

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 3-1SECTION IIIOPERATION3.1 POWER ON UNITTo power on the unit, rotate the Volume (VOL) knob

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 3-2before the five second delay is completed will return the radio to the Frequency mode an

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 3-3The Direct Tune mode is entered from the Standby Frequency Entry mode or Channel mode by

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 3-4FIGURE 3-1 KY 96A, KY 97A Controls

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page E-1APPENDIX EENVIRONMENTAL QUALIFICATION FORMS

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd RH-2THIS PAGE RESERVED

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page E-2THIS PAGE RESERVED

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page E-3FIGURE E-1 KY 96A Environmental Qualification Form

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page E-4FIGURE E-2 KY 97A Environmental Qualification Form

B TABLE OF CONTENTS KY 96A, KY 97ARev 4, Apr 2003 MM 006-00674-0004.dwd TOC-1SECTION IGENERAL INFORMATIONParagraph Page1.1 Introduction ...

B TABLE OF CONTENTS KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd TOC-22-9 KY 97A Interconnect... Dwg 155-01583

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 1-1SECTION IGENERAL INFORMATION1.1 INTRODUCTIONThis manual contains information relative to

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 1-2TABLE 1-1 Technical CharacteristicsSPECIFICATION CHARACTERISTICTSO COMPLIANCE:Transmitte

B KY 96A, KY 97ARev 4, Apr 2003 IM 006-00674-0004.dwd Page 1-3TRANSMITTEREMISSION: 6K 00A3EOCCUPIED BANDWIDTH: 25 kHzPOWER OUTPUT:KY 96A:KY 97A:5 watt